美國派克斯國際Solidaire?干燥系統（Bepex）-金陵干燥

Solidaire®干燥系統設有一個帶夾套的圓柱與一個高速槳轉子，創造一個非常激動的，密集的，薄薄的一層材料對夾套容器壁。這結果在無與倫比的傳熱系數。此干燥機的可調槳可以傳達與流動性差的材料，以及適應在輸送的材料，其在干燥過程中的流量特性的變化的變化。材料的停留時間范圍從一分鐘至約15分鐘。

Solidaire®干燥系統還可以處理熱敏感的材料，包括自由流動的固體濕餅和泥漿。高級氣體接觸的查詢結果在濕球溫度的材料溫度在恒定的速率干燥期間，消除了需要真空。這個過程的Solidaire®干燥系統也非常適合低密度，顆粒細，否則可能會被流化機械或氣動攪拌設備。

Solidaire®烘干系統有三種工作模式：

1。間接熱交換，其中，通過圓筒形殼體的熱傳導。這種熱的處理方法，以及適合于溶劑的蒸發過程，其中一個小的惰性吹掃氣的逆流流動，增加傳質速率。

2。直接熱傳遞，另一個熱加工的方法，其中，使用大體積的氣體的對流熱量傳遞。直接熱傳遞被施加的材料和氣體使用順流。這兩種組分被分離在旋風分離器或袋式過濾器的下游。

3。可以使用的組合，直接和間接傳熱優化能源效率，同時也降低了材料的溫度。

對于食品應用，Solidaire®干燥系統的專利噴墨轉子設計允許注入的氣體或液體通過槳葉沿圓柱形壁的單位中的螺旋流動的材料成薄層。這種能力注入的材料的溫度的較佳位置和揮發，可以有利于產品質量。通常用于烹飪，反應，或消毒的設計。

為Solidaire®干燥系統的應用 干燥 ABS 縮醛樹脂 酸，有機 農業化學品 銨diurinate  - 丁二烯 - 苯乙烯膠乳 血，凝結 羧甲基纖維素 醋酸纖維素 乙酸丁酸纖維素 木炭 磨成粉的咖啡 玉米粉 玉米淀粉 硅藻土 魚蛋白 石膏 除草劑 殺蟲劑 間苯二甲酸 二氧化錳 磷酸鎂 農藥 制藥 磷 聚 聚乙烯 聚丙烯 聚醋酸乙烯酯 聚氯乙烯 對苯二甲酸 氯乙烯穩定劑 小麥淀粉 氫氧化鋅

結晶 聚酯顆粒

冷 對苯二甲酸二甲酯 混合食品 聚烯烴 對苯二甲酸 三聚磷酸鈉

加熱反應 硝酸銨 六亞甲基二胺 胡椒 聚碳酸酯和添加劑 石英砂 淀粉 小麥和大豆濃縮

The Solidaire® Drying System features a jacketed cylinder with a high-speed paddle rotor that creates a highly agitated, dense, thin layer of material against the jacketed vessel wall. This results in unsurpassed heat transfer coefficients. This dryer's adjustable paddles can convey materials with poor flowability, as well as adapt to variations in the conveyance of materials whose flow characteristics change during drying. Material residence times range from under one minute to about 15 minutes.

The Solidaire® Drying System also processes heat-sensitive materials ranging from free-flowing solids to wet cakes and slurries. Superior gas contact results in material temperatures at the wet bulb temperature during constant rate drying, eliminating the need for vacuum. This process of the Solidaire® Drying System is also ideally suited to low density, fine particles that might otherwise be fluidized in mechanically or pneumatically agitated equipment.

The Solidaire® Drying System has three operating modes:

1. Indirect heat transfer, where heat is conducted through the cylindrical housing. This thermal processing method is well suited to solvent evaporation processes where a small counter-current flow of an inert sweep gas increases the rate of mass transfer.

2. Direct heat transfer, another thermal processing method, in which heat is transferred by convection using a large volume of gas. Direct heat transfer is applied using a co-current flow of material and gas. The two components are separated downstream in a cyclone or bag filter.

3. A combination, of indirect and direct heat transfer can be used to optimize energy efficiency while also reducing the material temperature.

For food applications, the Solidaire® Drying System's patented jet rotor design allows injection of a gas or liquid through the paddles into the thin layer of material flowing in a spiral along the cylindrical wall of the unit. This ability to inject at the optimum location for the material temperature and the volatile can benefit product quality. The design is often used for cooking, reacting, or sterilizing.

Applications for the Solidaire® Drying System DRYING ABS Acetal resins Acids, organic Agricultural chemicals Ammonium diurinate Butadiene styrene latex Blood, coagulated Carboxymethylcellulose Cellulose acetate Cellulose acetate butyrate Charcoal Coffee, ground Corn meal Corn starch Diatomaceous earth Fish protein Gypsum Herbicides Insecticides Isophthalic acid Magnesium dioxide Magnesium phosphate Pesticides Pharmaceuticals Phosphor Polybutylene Polyethylene Polypropylene Polyvinyl acetate Polyvinyl chloride Terephthalic acid Vinyl chloride stabilizer Wheat starch Zinc hydroxide

CRYSTALLIZATION Polyester pellets

COOLING Dimethyl terephthalate Food mixes Polyolefins Terephthalic acid Tripolyphosphate

HEATING & REACTION Ammonium nitrate Hexamethylenediamine Pepper Polycarbonate & additives Silica sand Starch Wheat & soybean concentrate

聯系方式：

公司名稱：江蘇金陵干燥科技有限公司

聯 系 人：查經理

電      話：13906113700

網      址：http://www.jinlingdry.com

地      址：江蘇省常州市鄭陸鎮三河口